The Origin of the Four-Stroke Cycle - Revision history

Toro Andersen at 12:13, 22 March 2026

2026-03-22T12:13:15Z

← Older revision		Revision as of 12:13, 22 March 2026
Line 143:		Line 143:
	----We do not own this work, it is here for educational purposes. The document this was transctibed from was freely awailable on the internet.		----We do not own this work, it is here for educational purposes. The document this was transctibed from was freely awailable on the internet.
	[[index.php?title=Category:Article]]		[[index.php?title=Category:Article]]
			[[Category:Articles]]

Toro Andersen at 20:14, 3 February 2025

2025-02-03T20:14:19Z

← Older revision		Revision as of 20:14, 3 February 2025
Line 18:		Line 18:
	Section 6 of the book contains various interesting proposals for combinations of gas and steam engines. The exhaust heat of a gas		Section 6 of the book contains various interesting proposals for combinations of gas and steam engines. The exhaust heat of a gas

	engine, for example, could be used to generate steam for a steam engine, Beau de Rochas says. Steam and gas could be used in different cylinders, or on opposite sides of the piston in the same cylinder, with the steam used to get the engine started and up to the speed required by a gas engine. This section includes an interesting statement of the conditions for maximum efficiency of a gas engine: the piston speed should be as high as possible, and the expansion should proceed as far as possible. Cylinder space should have as low a surface-to- volume ratio as possible, so that one large cylinder would be better than several small ones. The initial pressure should be as high as possible, but a practical limit is set by the temperature at which the charge will ignite spontaneously, which will be reached, Beau de Rochas guesses, with a compression ratio of about four to one. (It is interesting to note that Beau de Rochas mentions the possibility of spontaneous ignition of a compressed charge. One could stretch a point and argue that he an- ticipated Diesel as well as Otto, but what is being compressed in his hypothetical engine is a mixture of fuel and air. There is no indication that Beau de Rochas thought of reaching high temperatures by compressing air alone, as Diesel did.)		engine, for example, could be used to generate steam for a steam engine, [[Beau de Rochas]] says. Steam and gas could be used in different cylinders, or on opposite sides of the piston in the same cylinder, with the steam used to get the engine started and up to the speed required by a gas engine. This section includes an interesting statement of the conditions for maximum efficiency of a gas engine: the piston speed should be as high as possible, and the expansion should proceed as far as possible. Cylinder space should have as low a surface-to- volume ratio as possible, so that one large cylinder would be better than several small ones. The initial pressure should be as high as possible, but a practical limit is set by the temperature at which the charge will ignite spontaneously, which will be reached, Beau de Rochas guesses, with a compression ratio of about four to one. (It is interesting to note that Beau de Rochas mentions the possibility of spontaneous ignition of a compressed charge. One could stretch a point and argue that he an- ticipated Diesel as well as Otto, but what is being compressed in his hypothetical engine is a mixture of fuel and air. There is no indication that Beau de Rochas thought of reaching high temperatures by compressing air alone, as Diesel did.)

	As an incidental part of this theoretical analysis of the gas engine, Beau de Rochas suggests that a four-stroke cycle will make it possible to achieve the compression within the working cylinder and defines the four strokes as follows (Fig. 1): <blockquote>1. aspiration pendant une course entiére du piston; (suction during an entire stroke of the piston)		As an incidental part of this theoretical analysis of the gas engine, Beau de Rochas suggests that a four-stroke cycle will make it possible to achieve the compression within the working cylinder and defines the four strokes as follows (Fig. 1): <blockquote>1. aspiration pendant une course entiére du piston; (suction during an entire stroke of the piston)
Line 142:		Line 142:
	#Otto’s deposition, abstracted in Engineer, LX (1885), 433-34, says that he built a Lenoir model in 1861 or 1862, that he used the cylinder for another purpose in 1862 or 1863, and that he understood the advantages of compression in 1862 or 1863. He says nothing about an engine with more than one cylinder.		#Otto’s deposition, abstracted in Engineer, LX (1885), 433-34, says that he built a Lenoir model in 1861 or 1862, that he used the cylinder for another purpose in 1862 or 1863, and that he understood the advantages of compression in 1862 or 1863. He says nothing about an engine with more than one cylinder.
	----We do not own this work, it is here for educational purposes. The document this was transctibed from was freely awailable on the internet.		----We do not own this work, it is here for educational purposes. The document this was transctibed from was freely awailable on the internet.
	[[Category:Article]]		[[index.php?title=Category:Article]]

Toro Andersen at 20:31, 1 February 2025

2025-02-01T20:31:26Z

← Older revision		Revision as of 20:31, 1 February 2025
Line 142:		Line 142:
	#Otto’s deposition, abstracted in Engineer, LX (1885), 433-34, says that he built a Lenoir model in 1861 or 1862, that he used the cylinder for another purpose in 1862 or 1863, and that he understood the advantages of compression in 1862 or 1863. He says nothing about an engine with more than one cylinder.		#Otto’s deposition, abstracted in Engineer, LX (1885), 433-34, says that he built a Lenoir model in 1861 or 1862, that he used the cylinder for another purpose in 1862 or 1863, and that he understood the advantages of compression in 1862 or 1863. He says nothing about an engine with more than one cylinder.
	----We do not own this work, it is here for educational purposes. The document this was transctibed from was freely awailable on the internet.		----We do not own this work, it is here for educational purposes. The document this was transctibed from was freely awailable on the internet.
			[[Category:Article]]

Toro Andersen at 13:32, 1 February 2025

2025-02-01T13:32:04Z

← Older revision		Revision as of 13:32, 1 February 2025
Line 73:		Line 73:
	When the automobile with the four-stroke engine was first publicly shown in Vienna in 1898, it bore the date 1877, which made it very significant for people interested in the famous Selden patent in the United States, which was applied for in 1879. When this car was next shown, in Paris in 1900, it bore the date 1875, as it still does in the Technical Museum in Vienna, which gives it precedence over Otto's patent of 1876 as well as Selden’s of 1879. The evidence for these dates is extremely shaky. The only support for the 1875 date is a recollection of a newspaper clipping describing a ride in the car in that year. But the clipping is missing, and no one has been able to find such a story in a Vienna newspaper.'''''<sup>31</sup>''''' One convincing piece of direct evidence is that the engine on this car uses a Marcus brush carburetor patented in 1882. It would be very strange if Marcus used this carburetor in 1875 and patented it in 1882. It would also be very strange if he used		When the automobile with the four-stroke engine was first publicly shown in Vienna in 1898, it bore the date 1877, which made it very significant for people interested in the famous Selden patent in the United States, which was applied for in 1879. When this car was next shown, in Paris in 1900, it bore the date 1875, as it still does in the Technical Museum in Vienna, which gives it precedence over Otto's patent of 1876 as well as Selden’s of 1879. The evidence for these dates is extremely shaky. The only support for the 1875 date is a recollection of a newspaper clipping describing a ride in the car in that year. But the clipping is missing, and no one has been able to find such a story in a Vienna newspaper.'''''<sup>31</sup>''''' One convincing piece of direct evidence is that the engine on this car uses a Marcus brush carburetor patented in 1882. It would be very strange if Marcus used this carburetor in 1875 and patented it in 1882. It would also be very strange if he used

	the four-stroke process in 1875 and said nothing about it later. Marcus himself made no claim of priority. The explanation that he was so eccentric that he did not care about patents is unacceptable. He clearly did care about patents; he took out thirty-eight of them between 1857 and 1893.'''''<sup>32</sup>''''' With all the litigation going on over Otto’s patents—Otto’s firm was engaged in twenty patent suits in western Europe during this period, including several in Vienna—hundreds of men had a vital interest in evidence of an engine operating on a fourstroke cycle before 1876, and dozens of patent attorneys were doing their best to find it, but no contemporary hint of Marcus's priority has been found. He patented improvements to the explosion motor in 1883 and built two-stroke and four-stroke engines in the same period for use as stationary power plants. In the period 1887-89, after Otto’s four-stroke claim was broken, a Marcus four-stroke engine was produced commercially and described widely in the technical press without any indication that it had been used to drive a car, although the articles say in a general way that the motor can be used to drive boats and carriages. The point featured in these articles is that with his carburetor and his electric ignition, Marcus had made liquid fuel practical so that his engines could be used anywhere.'''''<sup>33</sup>''''' A date around 1888 for Marcus’s automobile with the four-stroke engine would be consistent with the surviving evidence,'''''<sup>34</sup>''''' and it would place the car at the very time when vehicles with four-stroke motors were being built by Daimler and Benz and patented and described freely in the literature. The lack of documentary support for Marcus’s priority is sometimes explained on the theory that evidence favorable to Marcus has ~~dis~~		the four-stroke process in 1875 and said nothing about it later. Marcus himself made no claim of priority. The explanation that he was so eccentric that he did not care about patents is unacceptable. He clearly did care about patents; he took out thirty-eight of them between 1857 and 1893.'''''<sup>32</sup>''''' With all the litigation going on over Otto’s patents—Otto’s firm was engaged in twenty patent suits in western Europe during this period, including several in Vienna—hundreds of men had a vital interest in evidence of an engine operating on a fourstroke cycle before 1876, and dozens of patent attorneys were doing their best to find it, but no contemporary hint of Marcus's priority has been found. He patented improvements to the explosion motor in 1883 and built two-stroke and four-stroke engines in the same period for use as stationary power plants. In the period 1887-89, after Otto’s four-stroke claim was broken, a Marcus four-stroke engine was produced commercially and described widely in the technical press without any indication that it had been used to drive a car, although the articles say in a general way that the motor can be used to drive boats and carriages. The point featured in these articles is that with his carburetor and his electric ignition, Marcus had made liquid fuel practical so that his engines could be used anywhere.'''''<sup>33</sup>''''' A date around 1888 for Marcus’s automobile with the four-stroke engine would be consistent with the surviving evidence,'''''<sup>34</sup>''''' and it would place the car at the very time when vehicles with four-stroke motors were being built by Daimler and Benz and patented and described freely in the literature. The lack of documentary support for Marcus’s priority is sometimes explained on the theory that evidence favorable to Marcus has disappeared, perhaps because it has been deliberately suppressed. The Nazis are said to have destroyed evidence favorable to Marcus when they took over Austria in 1938, for Marcus was a Jew. It is true that Marcus memorials and monuments have had their ups and downs in Germany and Austria since 1933, but I doubt if evidence was deliberately destroyed. A more plausible case for suppression of evidence can be made in connection with the disappearance of certain documents sent to America to be used in the prolonged litigation over the Selden patent. Viktor Tischler, to whom Marcus left his technical models and documents on his death in 1898, sent something, presumably documents about Marcus, to a New York law firm, possibly for use in the suit brought by the Electric Vehicle Company against the Winton Com pany in 1900 for infringement of the Selden patent.'''''<sup>35</sup>''''' If these documents were used as exhibits, they would have been deposited with the court, and then when Winton settled the case out of court in 1903, they would have been withdrawn and turned over as provided in the settlement agreement to attorneys for the Selden interests. In any case, these documents, if there were any such documents, are now lost. One can guess, as historians have,'''''<sup>36</sup>''''' that they were suppressed by the Selden patent interests because they contained damaging evidence that Marcus had an automobile before 1879. One can also guess, as I hereby do, that Winton’s lawyers advised settlement precisely because they did not have such evidence. If the Winton party had proof of Marcus’s priority, why should it settle?

			Marcus made important contributions to the two toughest problems in the development of the automobile engine, carburetion and ignition, but he followed rather than preceded Otto in both the atmospheric engine and the four-stroke cycle. He was an admirable person and deserves a monument, but we should get the date right on the monument.'''''<sup>37</sup>'''''

			The last claim that we need to consider is that Otto himself anticipated his 1876 invention in his own experimental work in 1861 or 1862. In appraising this claim, we have practically no contemporary evidence to go on. We have only a few veiled references to some experimental engines in a few letters from Otto to his fiancée. Later evidence includes some testimony about those early years in patent litigation of the 1880’, a pamphlet published by Otto’s partner in 1886, after the German patent was broken,'''''<sup>38</sup>''''' and Otto’s own recollections written in 1889, twenty-eight years after the events that interest us.'''''<sup>39</sup>''''' At this distance, the recollections of any man, however honest, may show the effects of professional pride and financial interest, and the actual events may have been pretty confused and haphazard anyway. An experimenter like Otto in 1861 may not stick to one well-defined approach, but is more likely to be trying various approaches, in series or in parallel, and the different techniques and ideas are likely to blend into each other and be hard to distinguish or remember accurately. Furthermore, the hardware of one engine will not survive because it will be reconstructed for the next one, so that it will not be available for the historian’s examination. A single cylinder, like Otto’s experimental cylinder of 1876, will be used for half-a-dozen distinct processes, so that even if the hardware survives, it may not prove much. In any case, it would be difficult to demonstrate that Otto did or did not use a particular process.


			Otto’s first experimental motor, a one-cylinder model of a Lenoir, seems well authenticated. In this cylinder, he experimented with various times of ignition, sizes of charge, and fuel-air ratios in an attempt to get smooth burning rather than dangerous explosion of the gas, and one of the things he did in the summer of 1861 was to draw in a charge, compress it on the back stroke, and ignite it at the dead point. The resulting explosion startled Otto, and he noticed that it drove the flywheel through several revolutions. This, he wrote in 1889, was the starting point for a four-stroke engine.'''''<sup>40</sup>''''' This kind of casual experiment with a compressed mixture in 1861 is plausible, but that Otto went on to devise a mode of continuous operation of an engine with this kind of combustion is extremely doubtful. Otto does not say he did. What he says, twenty-eight years later as he looks back on this first experience with compression, is that this was the experience that got him started on the road to the four-stroke engine.

			There is more doubt about the next engine.'''''<sup>41</sup>''''' A mechanic named Zons testified in December 1885 that he had built a large four-cylinder engine for Otto in 1862, and that it had operated as a four-stroke engine.'''''<sup>42</sup>''''' Otto, in his 1889 reminiscences, referred to this engine as a four-stroke engine and said that he was so encouraged by his experience with compression in the Lenoir model that he decided to move at once to the construction of a full-size four-cylinder engine. Attached to the deposition of Zons is a drawing which has been reproduced a number of times showing this engine as he remembers it (Fig. 2). It has pairs of cylinders on opposite sides of a crankshaft with two pistons in each cylinder, one connected rigidly to the crankshaft and the other a free piston that was supposed to serve two functions: to protect the motor from damage from the shock of the explosions by being driven against a cushion of air trapped between the two pistons at each power stroke; and to achieve complete expulsion of the exhaust gases, which was regarded as essential in those days. The drawing shows the general arrangement of pistons, cylinders, and crankshaft, but gives no indication of valves, ignition, or control gear of any kind, so that even an expert cannot now say with certainty how the engine operated, if indeed the drawing represents a real engine; and the drawing is suspect because it is part of Otto’s effort to convince a German court that he used the four-stroke cycle before Beau de Rochas published the idea.
			[[File:Otto 1862.png\|alt=Figure 2\|thumb\|Figure 2 -A drawing made in 1885 to represent an engine that Otto was said to have built in 1861 or 1862 and to have operated as a four-stroke engine. Plate III of Eugen Langen, Vortrag . . . gebalten in der Sitzung des Kolner Bezirksvereins deutscher Ingenieure am 2. Mirz 1886. . . ]]
			All accounts of this engine rest on the deposition of Zons made in 1885 and the recollections of Otto written in 1889. There is no surviving hardware or contemporary drawing. Goldbeck and others who wish to date Otto’s invention of the four-stroke cycle as 1861 or 1862 rely heavily on a single contemporary document, a letter Otto wrote to his fiancée on January 14, 1862, in which he says that he has spent a few hours with Zons, that they achieved very good results, and that he expects that everything will soon turn out well.'''''<sup>43</sup>''''' This evidence seems very slight and ambiguous.

			If one wishes to speculate about this conjectural engine and to support Otto’s claim, one troublesome question that can be asked is: Why did Otto build a four-cylinder engine if he was not thinking of the four-stroke cycle? Such an engine, if it existed, would be persuasive evidence that Otto was thinking of the four-stroke cycle. But it is hard to believe that it existed. A four-cylinder gas engine using the four-stroke or any other cycle would have been a memorable achievement in 1862, and if Otto did build and experiment with such an engine, why didn’t he say so before the German patent suit in 1885? For the English patent suit earlier that same year, he was questioned and cross-questioned about his early experimental work. By this time, he certainly appreciated the significance of the four-stroke cycle, and the Beau de Rochas book was an issue at the trial. But at this time, Otto gave a good deal of information about his early work without saying anything about this engine at all'''''<sup>44</sup>''''' And if Otto had carried through the four-stroke process in a four-cylinder engine like this, the necessary control system for valves and ignition would have been sufficiently new and remarkable to be mentioned, one would think, and any record of it would have been the best kind of evidence of priority. But the drawing submitted to the German court, the drawing of Zons, has no indication of any kind of control device at all.

			In any case, such an engine with the free pistons could not have operated very long or very well, in the four-stroke mode or any other mode. Otto said that the engine was broken down by explosive shocks the same year and that he gave up hope of ever getting a direct-acting engine to run satisfactorily, so he turned to the atmospheric principle, which eventually gave him a good temporary solution.

			In 1876, after fifteen more years of experience with burning gases in cylinders and problems of control, ignition, and valves—at a critical time for the company when somebody had to come up with something new—Otto turned back to the old idea of a direct-acting compression engine. He was still nervous about those explosive shocks, but thought he could get along without free pistons and rely on a cushion of inert gases to absorb the shock. He tried half-a-dozen modes of operation with his experimental cylinder, including external compression and even the Lenoir process, and soon settled on internal compression with the four-stroke process.

			<nowiki></nowiki> *

			This was the origin of the four-stroke cycle, the first practical way of compressing the charge in the working cylinder, which doubled the efficiency of the heat engine in a single step. Beau de Rochas had some interesting casual thoughts about the possibility, but Otto built the engine, the ancestor of some 200 million automobile engines.

	== Reference ==		== Reference ==
Line 112:		Line 133:
	# Kurzel-Runtscheiner, p. 30; Ladislaus Jonasz, “Der Selden-Patentstreit und das Marcus’sche Automobil,” Aligemeine Automobil-Zeitung Wien, II (March 17, 1901), 4-5; V. Tischler, “Das Erste Marcus-Automobil,” Allgemeine Automobil-Zeitung Wien, XI (October 9, 1904), 13-15.		# Kurzel-Runtscheiner, p. 30; Ladislaus Jonasz, “Der Selden-Patentstreit und das Marcus’sche Automobil,” Aligemeine Automobil-Zeitung Wien, II (March 17, 1901), 4-5; V. Tischler, “Das Erste Marcus-Automobil,” Allgemeine Automobil-Zeitung Wien, XI (October 9, 1904), 13-15.
	#Nevins, pp. 308-9; Greenleaf, pp. 143-44.		#Nevins, pp. 308-9; Greenleaf, pp. 143-44.
	#The inscription on the monument to Marcus in the Resselpark near the Technische Hochschule in Vienna, which was erected in 1932 and restored in 1948, reads:		#The inscription on the monument to Marcus in the Resselpark near the Technische Hochschule in Vienna, which was erected in 1932 and restored in 1948, reads: Dem Wiener Mechaniker SIEGFRIED MARCUS 1831-1898 Erfinder des Benzinautomobils 1864
	Dem Wiener Mechaniker		#Eugen Langen, Vortrag des Herrn Kommerzienrat Eugen Langen gebalten in der Sitzung des Kolner Bezirksvereins deutscher Ingenieure am 2. Marz 1886. . .(Cologne, 1886).
	SIEGFRIED		#Excerpts from these reminiscences have been quoted in the works of Arnold Langen, Sass, and Goldbeck already cited, but they have not been published in full.
	MARCUS		#“Das war der Ausgangspunkt für einen Viertaktgasmotor.” Quoted in Arnold Langen, p. 28.
	1831-1898		#I have included the story of this engine in “The Silent Otto,” Technology and Culture, VII (1966), 184-200. Other accounts are in Sass, pp. 23-25; Arnold Langen, pp- 28-29; Goldbeck, Gebindigte Kraft, 29-31; and Kurt Schnauffer, “Nicolaus August Otros Vierzylinder-Viertakt Motor von 1861. Zum 100jahrigen Jubilium des Viertaktverfahrens,” Motortechnische Zeitschrift, XXIII (1962), 1-4. Langen, Goldbeck, and Schnauffer argue that this was a four-stroke engine, Sass insists it was not.
	~~Erfinder~~		#Arnold Langen, pp. 142-43.
	des ~~Benzinautomobils~~		#“Ehe ich weg fuhr war ich noch mehrere Stunden bei Z., wir erzielten noch recht giingstige Resultate & denke ich bald ganz in Ordnung zu kommen.” (Plate IV in Goldbeck, Gebindigte Kraft.) The date of January 14, 1862, is significant because it precedes the date of the patent application of Beau de Rochas, which was January 16, 1862.
	~~1864~~		#Otto’s deposition, abstracted in Engineer, LX (1885), 433-34, says that he built a Lenoir model in 1861 or 1862, that he used the cylinder for another purpose in 1862 or 1863, and that he understood the advantages of compression in 1862 or 1863. He says nothing about an engine with more than one cylinder.
			----We do not own this work, it is here for educational purposes. The document this was transctibed from was freely awailable on the internet.

Toro Andersen at 12:55, 1 February 2025

2025-02-01T12:55:24Z

← Older revision		Revision as of 12:55, 1 February 2025
Line 113:		Line 113:
	#Nevins, pp. 308-9; Greenleaf, pp. 143-44.		#Nevins, pp. 308-9; Greenleaf, pp. 143-44.
	#The inscription on the monument to Marcus in the Resselpark near the Technische Hochschule in Vienna, which was erected in 1932 and restored in 1948, reads:		#The inscription on the monument to Marcus in the Resselpark near the Technische Hochschule in Vienna, which was erected in 1932 and restored in 1948, reads:
	Dem Wiener Mechaniker		Dem Wiener Mechaniker
	SIEGFRIED		SIEGFRIED
	MARCUS		MARCUS
	1831-1898		1831-1898
	Erfinder		Erfinder
	des Benzinautomobils		des Benzinautomobils
	1864		1864

Toro Andersen at 12:54, 1 February 2025

2025-02-01T12:54:31Z

← Older revision		Revision as of 12:54, 1 February 2025
Line 113:		Line 113:
	#Nevins, pp. 308-9; Greenleaf, pp. 143-44.		#Nevins, pp. 308-9; Greenleaf, pp. 143-44.
	#The inscription on the monument to Marcus in the Resselpark near the Technische Hochschule in Vienna, which was erected in 1932 and restored in 1948, reads:		#The inscription on the monument to Marcus in the Resselpark near the Technische Hochschule in Vienna, which was erected in 1932 and restored in 1948, reads:
	~~{{align\|center\|~~Dem Wiener Mechaniker }}		Dem Wiener Mechaniker
	SIEGFRIED		SIEGFRIED
	MARCUS		MARCUS
	1831-1898		1831-1898
	Erfinder		Erfinder
	des Benzinautomobils		des Benzinautomobils
	1864		1864

Toro Andersen at 12:53, 1 February 2025

2025-02-01T12:53:07Z

← Older revision		Revision as of 12:53, 1 February 2025
Line 112:		Line 112:
	# Kurzel-Runtscheiner, p. 30; Ladislaus Jonasz, “Der Selden-Patentstreit und das Marcus’sche Automobil,” Aligemeine Automobil-Zeitung Wien, II (March 17, 1901), 4-5; V. Tischler, “Das Erste Marcus-Automobil,” Allgemeine Automobil-Zeitung Wien, XI (October 9, 1904), 13-15.		# Kurzel-Runtscheiner, p. 30; Ladislaus Jonasz, “Der Selden-Patentstreit und das Marcus’sche Automobil,” Aligemeine Automobil-Zeitung Wien, II (March 17, 1901), 4-5; V. Tischler, “Das Erste Marcus-Automobil,” Allgemeine Automobil-Zeitung Wien, XI (October 9, 1904), 13-15.
	#Nevins, pp. 308-9; Greenleaf, pp. 143-44.		#Nevins, pp. 308-9; Greenleaf, pp. 143-44.
	#The inscription on the monument to Marcus in the Resselpark near the Technische Hochschule in Vienna, which was erected in 1932 and restored in 1948, reads: Dem Wiener Mechaniker SIEGFRIED MARCUS 1831-1898 Erfinder des Benzinautomobils 1864		#The inscription on the monument to Marcus in the Resselpark near the Technische Hochschule in Vienna, which was erected in 1932 and restored in 1948, reads:
			{{align\|center\|Dem Wiener Mechaniker }}
			SIEGFRIED
			MARCUS
			1831-1898
			Erfinder
			des Benzinautomobils
			1864

Toro Andersen at 12:50, 1 February 2025

2025-02-01T12:50:32Z

@@ Line 65: / Line 65: @@
 Two of Marcus’s inventions in the 1860's were of special interest to people working on gas engines, although both were conceived with other applications in mind. They solved the two problems that had to be solved to make the internal-combustion engine usable in places without city gas and to make it applicable to vehicles—the liquid fuel problem and the ignition problem. In the 1850's, Marcus developed a hand-powered magneto-electric device useful for a military field telegraph without batteries. This led him to an electric ignition device for explosive mines, which was adopted by the Austrian, Prussian, and Russian armies, and which apparently brought Marcus enough income to support his other projects. By the 1880's, he had a reliable magnetoelectric ignition system for gas engines that could be driven by the engine itself.
-Another of Marcus’s inventions dating from the 1860’s was a large carburetor, or gasifier, for converting liquid petroleum into a flammable gas. This was intended as a portable gas-generating plant to make gas available beyond city gas systems, but its application to gas engines was obvious. To help get his carburetor patented in Prussia, Marcus went to Berlin to see Franz Reuleaux (1829-1905), a distinguished engineer who was a consultant to the patent office, and also an intimate friend of Eugen Langen, Otto’s partner, who at the time was working with Otto on an early gas engine known as the Otto & Langen, which operated on the atmospheric principle like a Newcomen  steam engine.'''''<sup>22</sup>''''' Reuleaux wrote to Langen promptly in great excite-
+Another of Marcus’s inventions dating from the 1860’s was a large carburetor, or gasifier, for converting liquid petroleum into a flammable gas. This was intended as a portable gas-generating plant to make gas available beyond city gas systems, but its application to gas engines was obvious. To help get his carburetor patented in Prussia, Marcus went to Berlin to see Franz Reuleaux (1829-1905), a distinguished engineer who was a consultant to the patent office, and also an intimate friend of Eugen Langen, Otto’s partner, who at the time was working with Otto on an early gas engine known as the Otto & Langen, which operated on the atmospheric principle like a Newcomen  steam engine.'''''<sup>22</sup>''''' Reuleaux wrote to Langen promptly in great excite ment, as he frequently did, to report that he had found a source of cheap gas that would make the Otto & Langen independent of gasdistribution systems, and suggested that he get in touch with Marcus.'''''<sup>23</sup>''''' It is not known if they actually met or corresponded, but it is a good guess that they knew of each other’s work. Later the firm bought a carburetor from Vienna'''''<sup>24</sup>''''' and Otto developed his own carburetor and his own electric ignition system.
 == Reference ==
@@ Line 89: / Line 97: @@
 # Such stories have appeared recently, e.g., in Allan Nevins, Ford: The Times, the Man, the Company (New York, 1954), pp. 97-98; and in William Greenleaf, Monopoly on Wheels: Henry Ford and the Selden Automobile Patent (Detroit, 1961), pp. 29-30.
 # Constant von Wurzbach, Biographisches Lexikon des Kaiserthums Osterreich (Vienna, 1867), p. 422.
-# In the earliest days of the gas engine, the key problem was how to moderate or cushion the explosive force of the combustion of illuminating gas. In a directacting engine in which the expanding gases drove the output directly through rigid rods and cranks (like an automobile engine), the explosions seemed destructive
+# In the earliest days of the gas engine, the key problem was how to moderate or cushion the explosive force of the combustion of illuminating gas. In a directacting engine in which the expanding gases drove the output directly through rigid rods and cranks (like an automobile engine), the explosions seemed destructive and dangerous, especially if the charge were compressed. A number of inventors, including Otto and Marcus, tried to solve the problem by inserting some sort of spring between the explosion and the output. This idea never worked. The atmospheric principle, clearly borrowed from steam-engine technology, offered the best solution in the 1860s. In an atmospheric gas engine, the combustion was used to create a vacuum through the quick cooling of the hot gases, enough of a vacuum so that atmospheric pressure would drive the piston back through a power stroke.

Toro Andersen at 12:20, 1 February 2025

2025-02-01T12:20:13Z

Show changes

Toro Andersen at 11:49, 1 February 2025

2025-02-01T11:49:44Z

← Older revision		Revision as of 11:49, 1 February 2025
Line 28:		Line 28:
	4. refoulement des gas brûlés hors du cylindre au quatriéme et dernier retour. (discharge of burnt gases out of the cylinder at the fourth and final return.)</blockquote>Actually Beau de Rochas seems rather apologetic about the four-stroke cycle. It is a possible way of compressing the charge, he seems to be saying, not necessarily the best way, but the best he can think of at the moment. He recognizes the obvious objection that it reduces the number of power strokes per revolution, but mentions the compensating advantage of the improved efficiency that will come with compression, and he goes on to suggest that by making the engine double-acting one can achieve at least a half-power engine, so to speak (à demi-effet), by which he means one with half as many power strokes per revolution as an ordinary steam engine.		4. refoulement des gas brûlés hors du cylindre au quatriéme et dernier retour. (discharge of burnt gases out of the cylinder at the fourth and final return.)</blockquote>Actually Beau de Rochas seems rather apologetic about the four-stroke cycle. It is a possible way of compressing the charge, he seems to be saying, not necessarily the best way, but the best he can think of at the moment. He recognizes the obvious objection that it reduces the number of power strokes per revolution, but mentions the compensating advantage of the improved efficiency that will come with compression, and he goes on to suggest that by making the engine double-acting one can achieve at least a half-power engine, so to speak (à demi-effet), by which he means one with half as many power strokes per revolution as an ordinary steam engine.

	This clear expression of the four-stroke idea, which seems so remarkable in retrospect, had no influence in the 1860’s and 1870’s. Perhaps nobody read it. I can find no evidence that anybody knew about it before a German manufacturer accused of infringement somehow discovered the pamphlet in 1883 and used it to invalidate Otto’s four-stroke claim in Germany the following year.'''''<sup>3</sup>''''' The obscurity of the		This clear expression of the four-stroke idea, which seems so remarkable in retrospect, had no influence in the 1860’s and 1870’s. Perhaps nobody read it. I can find no evidence that anybody knew about it before a German manufacturer accused of infringement somehow discovered the pamphlet in 1883 and used it to invalidate Otto’s four-stroke claim in Germany the following year.'''''<sup>3</sup>''''' The obscurity of the publication became an issue in 1885 in patent litigation in London. The British court finally refused to admit the booklet as evidence, even though the British Museum had acquired a copy, on the ground that it had not been really published in the sense of being made known and available to people interested in gas engines.'''''<sup>4</sup>''''' Not even Etienne Lenoir, \| the best-known gas-engine man of the day, gave any sign of interest in the four-stroke idea. He is supposed to have known Beau de Rochas'''''<sup>5</sup>''''' (they lived in the same city and had common interests, and Beau de Rochas mentions Lenoir in the book), so the idea should have reached him if it reached anybody, and at the time Lenoir badly needed ideas, for his engine was not working well. He had a double-acting engine like a steam engine that burned illuminating gas without compression, well advertised but not very efficient, which some of his customers were converting to steam because it was so uneconomical and rough running.'''''<sup>6</sup>''''' Even if the four-stroke idea had reached Lenoir or occurred to him, the proposal to improve the engine by reducing the frequency of power strokes might well have seemed too absurd to try.

			And apparently Beau de Rochas himself did not think well enough of the idea to keep his patent alive. He had applied for a patent on his collection of ideas on January 16, 1862, and later filed supplementary applications. The patent was granted, with supplements, but lapsed after a year, probably because the required annual fee was not paid.'''''<sup>7</sup>''''' It looks

	# “[[The Silent Otto]],” Technology and Culture, VII (Spring 1966), 184-200.		# “[[The Silent Otto]],” Technology and Culture, VII (Spring 1966), 184-200.
	# Information about Beau de Rochas is concentrated in two groups of articles— one in Bulletin de la Société d’ Encouragement pour VIndustrie Nationale, CXXXVII (1938), 209-39, especially C. Walckenaer, “L’invention de Beau de Rochas,” pp. 212 25; the other in Documents pour l'histoire des techniques, Cahier No. 2 [1962] pp. 3-42, especially Jacques Payen, “Beau de Rochas. Etude biobibliographique,” pp. 3-24, which contains a useful list of the known publications by and about Beau de Rochas.		# Information about Beau de Rochas is concentrated in two groups of articles— one in Bulletin de la Société d’ Encouragement pour VIndustrie Nationale, CXXXVII (1938), 209-39, especially C. Walckenaer, “L’invention de Beau de Rochas,” pp. 212 25; the other in Documents pour l'histoire des techniques, Cahier No. 2 [1962] pp. 3-42, especially Jacques Payen, “Beau de Rochas. Etude biobibliographique,” pp. 3-24, which contains a useful list of the known publications by and about Beau de Rochas.
	# The earliest reference I have seen is in a letter from C. Wigand dated December 14, 1883, published in Zeitschrift des Vereines deutscher Ingenieure, XXVIII (1884), 45-47.		# The earliest reference I have seen is in a letter from C. Wigand dated December 14, 1883, published in Zeitschrift des Vereines deutscher Ingenieure, XXVIII (1884), 45-47.
			# In Otto vs. Steel, reported in Engineer, LXI (1886), 9, 35-36, 93.
			# Friedrich Sass, Geschichte des deutschen Verbrennungsmotorenbaues von 1860 bis 1918 (Berlin, 1962), p. 57.
			# “Gasmaschine,” Jabresberichte iiber die Fortschritte der mechanischen Technik und Technologie, II (1864), 164-5.
			# French patent number 52,593, applied for January 16, 1862, delivered March 10, 1862, with an addition applied for June 10, 1862, delivered August 26, 1862 (C. Walckenaer, p. 216). The existence of a French patent at this time does not prove much. It does not prove that anybody had actually tried out the four-stroke cycle, or judged it workable, or intended to exploit it commercially. It was not the four-stroke cycle specifically that was patented, but rather the whole book in which the four-stroke cycle was only one of hundreds of ideas. A French patent was a simple registration of a claim, like a copyright, granted without any investigation to determine the novelty or utility of the invention. The arguments in the British and the German patent litigation seem to refer to the Beau de Rochas book, not the patent, perhaps because the patent was not known at the time. French law required an annual fee of one hundred francs to keep a patent alive and provided for an annual catalogue of new patents by title and for publication, verbatim or by extract, of patents on which the second annual fee had been paid (Thomas Barclay, The Law of France Relating to Industrial Property [London, 1889], p. 50). The title of the Beau de Rochas patent, which was the same as the book title, might not seem significant to a researcher, and the second annual fee was presumably not paid.